Mazda Car Battery Replacement

There can be many reasons why a battery has gone flat - here are the most common causes:

• Undercharging - This is the most common cause of a flat battery. Modern vehicle charging systems are designed to reduce CO₂ emissions and improve fuel economy by increasing battery usage, while at the same time not providing sufficient charge to fully recharge the battery. A flat battery may also be a result of a fault in the vehicle's charging system.
• Human Error - None of us are perfect. Leaving the headlights or interior lights on, or not closing the boot properly can all potentially flatten a vehicle's battery overnight.
• Parasitic drain - This is caused by components in the vehicle which continue to operate after the engine has been turned off. The most common offenders are dashcams, alarm systems, or electronic rust prevention systems. These items can gradually wear a battery down over time.
• Driving habits - If a vehicle is driven on a lot of small trips, the battery may not receive enough charge to recover the energy lost cranking the engine at the start of the journey. Lead-acid batteries also lose power gradually over time when not in use, so batteries in vehicles which are rarely driven will eventually end up going flat.
• Old battery - Old batteries are simply not as good at holding their charge - so if a vehicle consistently won't start it is possible that the battery has reached the end of it's life. Lead-acid batteries last 42 months on average, so if a battery is beyond this age it is on borrowed time.

If you've recently experienced a flat battery, it is important to have an expert investigate whether any problems exist with the vehicle's charging system before a new battery is fitted.

Almost all batteries have a natural tendency to go flat over time, especially when they're not in use. If you've got an old mobile phone stored in a draw at home, you'll notice it'll probably be flat the next time to try to turn it on - and it's the same story with the battery in your vehicle.

Lead-acid batteries lose charge over time, and this problem is often made worse by the parasitic drain of electrical devices within the vehicle which continue to operate even whilst parked. For vehicles which are rarely driven, a battery maintainer or trickle charger should be used to prevent the battery from self-discharging and going flat.

How long a battery lasts depends on:

There are a few easy things you can do to get the absolute maximum amount of life out of your battery. As a rule, the following items should be checked on a monthly or bi-monthly basis:

• Ensure the top of the battery is clean, and that the terminals are free of corrosion.
• Check the voltage with a voltmeter. 12.7 to 12.8v is considered to be fully charged.
• If your battery is below 12.5 volts, recharge immediately using a suitable smart battery charger.
• For maintainable batteries, remove the plugs and ensure that the electrolyte is covering the battery plates. Top up with distilled water if required. For maintenance free types, check the water indicator.
• We recommend charging batteries with an appropriate battery charger every 3 months to maintain peak performance.

There are a few signs that indicate your battery may be starting to go, including: 

• The engine cranks or turns over, but won't start
• The engine won't crank, and light and accessories don't turn on
• Your car battery shows signs of damage such as cracking, swelling and leaking
• You've needed to jump start your car a few times

If you suspect you have a flat battery or aren’t sure why you car won’t start, you can call 0404 096 583 to arrange for one of our expert mechanics to help you get back on the road. 

Lead-acid batteries last 42 months on average - however this figure may be reduced or extended depending on a number of factors, including:

• Whether the battery has been installed correctly.
• If the battery chosen is suitable for the vehicle and driving application.
• The climate in which the vehicle is driven.
• The voltage which the battery is usually kept at.
• Whether the vehicle has high or low parasitic drain when not in use.
• How often the vehicle is used, and the length of the journeys.
• Whether the battery and the vehicle itself have both been well maintained.

Based on these factors, batteries fitted to vehicles which are used in hot climates, driven on short journeys, and rarely maintained would be expected to have a shorter life. Conversely, vehicles which are used in milder climates, driven further, and receive regular maintenance would typically have a longer life.

CCA stands for Cold Cranking Amps and is the recognised industry standard for rating a battery's cranking performance. The number of plates was once used as the measure for rating batteries, however CCA is now the industry standard.

The Amp Hour (Ah) rating is a way of describing a battery's capacity. It describes the capacity of a battery based on a discharge period of 20 hours.

AGM stands for Absorbent Glass Mat. This type of battery uses a non-woven glass mat to separate the plates. The glass mat absorbs and retains sufficient electrolyte for the battery to operate, meaning that  there is no free electrolyte in the cell to spill. These batteries are also known as Valve Regulated Lead Acid (VRLA) batteries as each cell has a one-way valve to manage cell pressure. 

Enhanced Flooded Batteries (EFB) are being fitted to many vehicles fitted with Idle Stop Start (ISS) technology. These ‘flooded’ batteries are an enhanced version of the standard calcium battery, and are designed to withstand the increased cranking and cycling demanded by vehicles fitted with ISS technology.

Idle Stop Start (ISS) technology, also known as Stop Start, is designed to help reduce vehicle fuel consumption and emissions. The vehicle’s engine automatically shuts down when the vehicle is stationary instead of idling, and will restart when you need to move again. ISS equipped vehicles are fitted with EFB and AGM batteries which are designed to cope with the additional electrical loads and repeated cranking required from this technology.

Some vehicles are equipped with Battery Management Systems (BMS) which require new batteries to be registered with the system. In most instances, RACV Batteries technicians will perform this registration on applicable vehicles.

Sealed batteries are designed to only hold enough liquid to allow electrolytes within the battery to flow. 

Sealed batteries are known to be maintenance free. It’s not necessary to add distilled water to sealed battery cells, so no maintenance is needed. However, under normal conditions the fluid level will last for the life cycle of the battery. All our batteries are maintenance free.